dairy equipment Articles

  • Dairy farm Oklahoma, USA

    Type of Wastewater System: Facility to Sediment Basin for Solids collection, Sediment Basin to Lagoon for Water collection Expectations: This facility was in need of solid removal from sediment basin as it was to a point of water flow restriction and solid capacity in the sediment basin. The expectation was to liquefy the solids in the sediment basins using microbial ...


    By Roebic Laboratories, Inc.

  • Dairy Processing - Case Study

    Introduction Clean Water Technology, Inc., the creator of the Gas Energy Mixing (GEM) System, offers the most advanced primary treatment system on the market. The GEM System provides superior reduction of total suspended solids (TSS), biological and chemical oxygen demand (BOD/COD), fats, oils and grease (FOG) and turbidity. Challenge A premier processor of ...


    By Clean Water Technology, Inc.

  • Dairy Processor- Dairy Farmers of America, Hughson, CA USA

    The dairy processor manufactures dehydrated milk products for the national market. This long established business prides itself in good management, manufacturing and citizenship. But increasing city wastewater treatment surcharges for TSS and BOD necessitated attention. The dairy had been contacted by WWW in the past, and were familiar with their success at other dairy processing facilities. The ...


    By World Water Works, Inc.

  • Industrial Fans for Food and Dairy Processing

    Important Considerations Required in Fans for Food and Dairy Processing Manufacturers of food and dairy products are well aware that there are increased Federal and State guidelines that impact their operations in the interest of greater health and safety. Industrial fans for food and dairy processing are no different. Industrial fans play a pivotal role in keeping this equipment ...


    By AirPro Fan & Blower Company

  • Farm digesters for small dairies in Vermont

    THROUGH its award-winning Cow Power program, Central Vermont Public Service (CVPS), a Vermont utility headquartered in the city of Rutland, is helping dairy farmers diversify their incomes by turning manure into electricity. The farmers process manure in anaerobic digesters to generate power, which CVPS customers voluntarily pay a premium to purchase. In addition to income from electricity sales, ...


    By BioCycle Magazine

  • Dairy farm New Mexico, USA

    Type of Wastewater System: Facility to Lagoon For Solid and Wastewater Collection Problem: This facility has an expensive liner in its lagoon, and the use of equipment to remove the solids from the lagoon was not an option. It also dewaters the lagoon via irrigation onto row crops every 30 days. The buildup of solids in the lagoon had reached a point of capacity such that they ...


    By Roebic Laboratories, Inc.

  • Dairy Processor- Wilcox Farms, Salem OR, USA

    The dairy processor manufactures a wide variety of products for the local market. This long established community based business prides itself in good management, manufacturing and citizenship. But when the city wastewater treatment surcharges for TSS and BOD passed $20,000 per month to greater than $30,000 per month, in less than a year, action became necessary. The dairy had been contacted by ...


    By World Water Works, Inc.

  • Confidential Client, Dairy Farm, Pennslyvania - Case Study

    In July 2011, AdEdge Water Technologies was selected by CET Engineering Services and the client via a competitive bidding process to design, manufacture, and commission a packaged nitrate removal system for a food processing plant in Pennslyvania. The existing water system is a 0.7 MGD system consisting of a single well pump feeding multiple atmospheric storage tanks coupled with final UV ...

  • Asian dairy churns out grade AA effluent

    ' The AIRE-O2® aerators have excellent oxygen transfer, easy maintenance and operation.' Problem Founded in 1937, this dairy cooperative located in Asia has played a leading role in the development of the industry in its country. Its mission is to 'supply quality products for safe-guarding the nation’s health' in all its product line. The same attention to quality standards that drives ...

  • Lowara booster sets used for dairy production

    The Italian producer relies on Xylem to make the world’s favourite cheese. It’s the most consumed – and imitated – cheese in the world, with 4 million wheels produced in more than 30 provinces of northern Italy every year. In the province of Cremona, Xylem Lowara pumps are critical to the production of this internationally renowned hard cheese. The dairy ...


    By LOWARA - a Xylem brand

  • Dredge Dealer Dairy Specialists Wins Business Ethics Award

    Dairy Specialists, an SRS Crisafulli agricultural dredge dealer for more than two years, was awarded with the Colorado-based CEBA Bill Daniels Business Award in March for conducting every aspect of its business ...


    By SRS Crisafulli, Inc.

  • CAF Failure: www/RESOURCE DAF Success!

    This dairy manufactures fluid milk, dairy-based mixes, yogurts, and juices. For several years, the facility was using a CAF system to treat its wastewater prior to discharge. The system performed inconsistently and operational costs approached $14/1000 gallons treated. The city could not tolerate the inconsistent performance and the dairy couldnot afford the costs to operate the system. Many ...


    By World Water Works, Inc.

  • Adding Value To On-Farm Digesters

    ANAEROBIC digestion of dairy manure and food processing residuals in Michigan is not a new undertaking. Over the years, 11 farm digesters were constructed in the state, of which four are still operational, reports Michelle Crook of the Michigan Department of Agriculture in a presentation in the spring of 2007. “Three of the operating digesters are for livestock manure and one is for food ...


    By BioCycle Magazine

  • Zone tillage depth affects yield and economics of corn silage production

    Increasing numbers of dairies in northeastern United States are classified as confined animal feeding operations (CAFOs). Many dairy farmers in New York (NY) abandoned conventional and adopted zone tillage (ZT) in 4-yr corn (Zea mays L.) silage-alfalfa (Medicago sativa L.) rotations on highly erodible land to comply with NY CAFO plans. Farmers now question optimum ZT depth because of increased ...

  • Zone tillage depth affects yield and economics of corn silage production

    Increasing numbers of dairies in northeastern United States are classified as confined animal feeding operations (CAFOs). Many dairy farmers in New York (NY) abandoned conventional and adopted zone tillage (ZT) in 4-yr corn (Zea mays L.) silage-alfalfa (Medicago sativa L.) rotations on highly erodible land to comply with NY CAFO plans. Farmers now question optimum ZT depth because of increased ...

  • Syracuse, New York: AD Adds To Dog Treat Bakery’s Sustainability

    Full Circle Feed in Syracuse makes healthy, environmentally-sustainable dog treats with unused meats, vegetables, fruits, and breads from restaurant buffets that were prepared but not served. It recently won the grand prize of $10,000 in Green America’s Fall 2016 People & Planet contest in the category of sustainable products and services for pets and animals. “Full Circle Feed ...


    By BioCycle Magazine

  • Latest Progress in Anaerobic Digestion

    Compared to countries like Germany and Denmark, the United States and Canada have a long way to go in creating the fundamental policy incentives and regulatory mandates that will encourage market development for anaerobic digestion (AD). Someone recently asked me how many years it would take to deploy AD systems on farms in North America that are large enough to economically use them. Given ...


    By BioCycle Magazine

  • Compost Users Forum: The Applied Thoughts Of A Compost Theorist

    WITHIN a 60-mile radius of my office here in central California, there are 1,000 dairies — each having an average of 2,000 cows. They generate over four million tons of manure annually, so we are pretty much in the manure business whether we want to be or not. Somebody has to manage this material and help the farmers utilize it properly, fulfilling its potential monetary value. That’s what we ...


    By BioCycle Magazine

  • Digester Developer Taps Natural Gas Markets

    IN the late 1990s, Dan Eastman and two colleagues were researching business opportunities in the renewable energy industry. They were looking for a commercially viable technology that could take renewable energy from an experimental phase to a solid business investment. In 1999, Eastman and his partners founded Microgy, Inc., with its base in Wisconsin. The company licensed the Xergi anaerobic ...


    By BioCycle Magazine

  • Implementing Research : Georgia Takes Many Routes to Recycle Food Residuals

     PETROLEUM HYDROCARBON LEVELS “One unique local characteristic (and treatment difficulty) we encountered in our composting program,” says Stan Konno, PWC environmental department director head, “is the high level of diesel range total petroleum hydrocarbon (TPH) content in the sludge from the WWTF at Fort Kamehameha.” Oil from past leaks in pipelines and tanks — which go back to 1941 — ...


    By BioCycle Magazine

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you