dairy technology Articles

  • Dairy Processing - Case Study

    Introduction Clean Water Technology, Inc., the creator of the Gas Energy Mixing (GEM) System, offers the most advanced primary treatment system on the market. The GEM System provides superior reduction of total suspended solids (TSS), biological and chemical oxygen demand (BOD/COD), fats, oils and grease (FOG) and turbidity. Challenge A premier processor of ...


    By Clean Water Technology, Inc.

  • Anaerobic Digestion at Dairy Farms

    The need to upgrade dairy waste management practices to overcome pollution problems is leading more farmers to seek solutions with anaerobic digestion technology. Two recent examples of this trend are underway at California sites. The Cal Poly Dairy is located adjacent to the California Polytechnic State University campus in San Luis Obispo. The dairy milks 180 cows with a total population of ...


    By BioCycle Magazine

  • Brazilian Dairy with Space Constraints

    Case Study of a Brazilian Dairy - Space Constraints The Challenge:  The customer is a producer of dairy products including:  milk, cheese, sour cream, butter and yogurt.  In Sao Paulo City as in many large cities, the industries have to pay to discharge to the municipal wastewater system.  The dairy was no exception.  The immediate challenges they were facing were scaling ...


    By Biowater Technology

  • Sabar Dairy CHP - Case Study

    Sabarkantha District Co-operative Milk Producers Union started in 1964, and has progressed to a fully integrated milk processing organisation involved in reception, pasteurisation, condensing, chilling and the supply of milk & milk products. The organisation is one of the biggest co-operative milk producers unions in ...


    By Clarke Energy

  • Himmerland dairy farm case study

    A. PRE-TREATMENT Barn Type: 60 tie stall dairy barn. Mats used in stalls. Manure Handling: Barn houses about 17 – 20 cows along each of two 120 foot parallel pits 2.5 feet wide and 5 to 9 feet deep (stepped). The pits gravity drain to the center of the pit and then flow out to an outside manure storage pit via 2.5 foot square pipe. Half of south gutter is used to handle parlour wash. ...


    By Nordevco Associates Ltd.

  • Farm digesters for small dairies in Vermont

    THROUGH its award-winning Cow Power program, Central Vermont Public Service (CVPS), a Vermont utility headquartered in the city of Rutland, is helping dairy farmers diversify their incomes by turning manure into electricity. The farmers process manure in anaerobic digesters to generate power, which CVPS customers voluntarily pay a premium to purchase. In addition to income from electricity sales, ...


    By BioCycle Magazine

  • Confidential Client, Dairy Farm, Pennslyvania - Case Study

    In July 2011, AdEdge Water Technologies was selected by CET Engineering Services and the client via a competitive bidding process to design, manufacture, and commission a packaged nitrate removal system for a food processing plant in Pennslyvania. The existing water system is a 0.7 MGD system consisting of a single well pump feeding multiple atmospheric storage tanks coupled with final UV ...

  • Digested Dairy Manure To High-End Potting Soil

    Robert Joblin and Ted Sniegocki of Cenergy USA based in Little Rock, Arkansas, are not horticulturalists or agronomists. But they are anaerobic digester developers and when falling rates for renewable energy and the loss of the federal Investment Tax Credit grant hit at the same time, the financial models they had been using “fell down.” The need for additional revenue streams for AD ...


    By BioCycle Magazine

  • Dairy Digester Opens Doors On Maryland Farm

    Kilby Inc., a 600-cow dairy operation located in Colora, Maryland, has the only operational commercial anaerobic digestion (AD) system in the state. In 2009, Kilby Inc. (the dairy farm and milk production business) began construction of a covered lagoon digester, which started operating in March 2011. The digester input consists of flushed cow manure (98% by volume) and food waste (2%), including ...


    By BioCycle Magazine

  • New manure digester generates heat at World Dairy Expo

    For anyone visiting the World Dairy Expo, there can be a lot to digest. The world's largest dairy trade show begins Tuesday at Alliant Energy Center. Around 65,000 people are expected to attend. There are 752 companies and organizations exhibiting and there will be approximately 3,000 cows on the grounds. There will be 14 cattle shows, eight virtual farm tours and the Badger Dairy Club ...


    By Himark bioGas Inc

  • Analysis of competitiveness of a dairy property through reverse logistics: a case study

    This paper aimed at evaluating the competitiveness of a dairy property located in the Western Paraná State that uses the reverse logistics of the animal waste produced by the activity. Therefore, we collected information related to the property and the activity by questionnaires and in loco observations seeking information regarding the drivers that affect the competitiveness of the property, ...


    By Inderscience Publishers

  • Maintenance strategies for on-site water disinfection by ultraviolet lamps on dairy farms

    Bacteria have been detected in many water supplies on dairy farms, and the water used to wash milking equipment should be free of bacteria. This study evaluated two ultraviolet (UV) technologies, with and without automatic sleeve cleaning device, as on-farm water disinfection system. No fouling was observed during 6 months of continuous operation of the self-cleaning UV system. The dose provided ...


    By IWA Publishing

  • Current situation and the development of the dairy industry in Jordan, Saudi Arabia, and Syria

    Abstract The development of the dairy industry plays an important role in the economy of Middle Eastern countries. Judged by its growth rate, the dairy industry is viewed as one of the most progressive food industries in the Middle East. During the early 1970s, countries established executive programs to promote dairy farming; the major objective was to attain self-sufficiency in ...


    By IFCN dairy research center

  • Applying low-charge ammonia systems to an operating dairy facility - Case-Study

    The ATMOsphere Review Panel has selected ammonia case studies from Evapco and Bohn de Mexico to be presented at ATMOsphere America 2017. Taking place in Loews Coronado Bay Resort, San Diego, ATMOsphere America 2017 serves as the leading forum for discussion about the business case for natural refrigerants in North America. Over 400 participants from the US, Canada, Mexico ...


    By Evapco Inc.

  • Dredge Dealer Dairy Specialists Wins Business Ethics Award

    Dairy Specialists, an SRS Crisafulli agricultural dredge dealer for more than two years, was awarded with the Colorado-based CEBA Bill Daniels Business Award in March for conducting every aspect of its business ...


    By SRS Crisafulli, Inc.

  • LBV Captures Biogas from Anaerobic Digestion of Dairy Wastewater

    The Customer: Laticínios Bela Vista Ltda. (LBV) is the fifth largest dairy food producer in Brazil with three plants processing over 3 million liters of milk per day. The company makes over 100 different products for LBV’s brands: Piracanjuba, Pirakids, Leitbom, and others. The Customer’s Needs: LBV expanded their plant in Bela Vista de ...

  • 3 Tips on How to Keep Dairy Barns Bird-Free

    Controlling birds around farm buildings can take time out of your already strict daily routines. Nuisance birds like pigeons, starlings and barn swallows don’t care about anyone’s schedule but their own. Unfortunately, sharing the barn with pest birds isn’t sanitary and the costs and dangers of birds in dairy and livestock operations can add up quickly! See how to keep ...


    By Avian Enterprises, LLC

  • Affordable new compost technology provides in-vessel levels of gas emission and odor control

    Increasingly stringent air-emission regulations and demands to better control odors has put an economic strain on industries that recycle large amounts of organic materials, such as compost facilities, dairies, and feedlots. ECS has recently introduced an affordable composting technology to greatly improve facility compliance and odor control. This technology is the AC Composter. Air Quality ...


    By Engineered Compost Systems

  • Farm digester progress in Pennsylvania

    The Commonwealth of Pennsylvania is home to about 7,000 dairy farms with an average herd size of less than 100 cows. While nutrient and odor management are of great importance to these farms, their overall economic viability appears to be the primary factor driving installation of anaerobic digesters over the past few years. “Pennsylvania has 30 dairy digesters and about 5 swine digesters ...


    By BioCycle Magazine

  • Regional roundup

    ANAEROBIC DIGESTER ON UNIVERSITY CAMPUS The University of Guelph’s Ridgetown Campus, part of the Ontario Agriculture College (OAC), received an investment of more than US$2.6 million for construction of an anaerobic digester through the Federal Development Agency for Southern Ontario. OAC, with its Center for Agricultural Renewable Energy and Sustainability, views the digester as “a ...


    By BioCycle Magazine

Need help finding the right suppliers? Try XPRT Sourcing. Let the XPRTs do the work for you